Products

Partial Replacement of Fine Aggregates with Quarry Dust in .

Keywords: Alternate building materials, Concrete, Quarry Test procedures Dust, aggregates Compressive strength of quarry dust mortars: The materials required.

Strength Studies on Metakaolin Modified Cement Mortar with .

This paper presents the results of a study to use metakaolin in cement mortar as a partial replacement of cement where quarry dust was used as the fine aggregate. The effect of water binder ratio and metakaolin replacement level on the compressive strength of cement quarry dust mortar .

Partial Replacement of Sand by Quarry Dust in Concrete

quarry waste and its effect on the strength and workability of concrete. This paper . proportions of cement concrete + quarry dust (M 20, AND M25). The experimental .. TABLE 5: Results for Compressive Strength Test for. Quarry Dust mix.

Development and Study of the Strength of Self-Compacting Mortar .

Rice husk ash (RHA) and quarry dust (QD) are two such waste materials, the use . The compressive strengths of a control SCM mix (without RHA and QD) and.

USE OF DUNE SAND AS AN ALTERNATIVE FINE AGGREGATE .

USE OF DUNE SAND AS AN ALTERNATIVE FINE AGGREGATE IN CONCRETE AND MORTAR R. Sanjeevan 1, S. Kavitha2, . According to the results compressive strength of mortar is higher than . due to the combined effect of particle shape of dune sand and quarry dust. Mortar with dune

Strength and Durability Studies on Concrete Using Quarry Dust as .

and flexural strengths besides durability of concrete made with Quarry Dust have been investigated. Cement Concrete mix using Quarry Dust as Fine Aggregate.

a case study of stone crushing industry of Sylhet - BENJapan

carefully proportioned mixture of cement, sand and gravel or other aggregates .. ratio 1:3.5 stone dust has higher compressive strength for 3,. 7, and 28 days.

QUARRY DUST FINE POWDER AS SUBSTITUTE FOR .

Quarry Dust Fine Powder as Substitute for Ordinary Portland Cement in Concrete Mix 193 Journal of Engineering Science and Technology April 2014, Vol. 9(2) enhances compressive strength at hardened state [3]. However, there is still limited information on the behaviour of concrete properties with the inclusion of different

Strength aspect of concrete using stone dust as a partial .

Keywords: Stone Dust, Concrete, Compressive Strength, Tensile Strength. . strength at 50% sand replacement by quarry dust. It . hardened cement concrete.

Behaviour of Concrete on the Use of Quarry Dust and .

comparing compressive strength of concrete in which river sand is partially replaced by quarry dust . to replacement, super plasticizer is used depending upon the weight of cement. Keywords: Quarry dust, Superplasticizer, Compressive strength, Slump value . addition to concrete or mortar allows the reduction of the water to cement ratio and .

STUDY ON PERFORMANCE OF QUARRY DUST AS FINE .

Key Words: Quarry dust, compressive strength, split tensile strength, reinforced-concrete. INTRODUCTION Quarry dust is the residue of particles in the size range of 0 – 4.75mm obtained as a byproduct in the later stages of crushing of igneous rock, sedimentary rock or gravel.

An Innovative Method of Replacing River Sand by Quarry Dust . - Ijser

other concrete mix ratios and also cement mortar mixes which is used for ceiling and .. sand, the compressive strength increased by 3.98%, flexural strength.

Partial Replacement of Sand by Quarry Dust in Concrete

4. [5]According to the value of compressive strength collected, the value is high and it show that quarry dust suitable to use as sand replacement. All the value of compressive strength surpasses the minimum value of compressive strength for normal concrete that is 7N/mm . So, quarry dust can apply as sand replacement in

Aging and Curing Temperature Effects on Compressive .

Aging and Curing Temperature Effects on Compressive Strength of Mortar Containing Lime Stone Quarry Dust and Industrial Granite Sludge Article (PDF Available) in Materials 10(6):642 · June 2017 .

Use of Quarry Dust to Replace Sand in Concrete – An .

clear picture that quarry dust can be utilized in concrete mixtures as a good substitute for natural river sand giving higher strength at 50% replacement. Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION oncrete is the most widely used composite material today.

Study on Compressive Strength of Quarry Dust as Fine Aggregate in .

Jun 30, 2016 . Study on Compressive Strength of Quarry Dust as Fine Aggregate in . to the normal mortar mould at 7 and 28 days for tensile strength which.

The compressive strength of mortar made with cement .

The compressive strength of mortar made with cement containing limestone mineral addition, cement kiln dust and fly ash B T. Benn University of South Australia D Baweja University of Technology, Sydney J E. Mills University of South Australia [email protected] is an electronic repository administered by Southern Cross University Library.

Strength Characteristics of Quarry Dust in . - IOPscience

Gopalakrishnan et al. -. Study on Strength of Hybrid Mortar . of sand with quarry dust. Key Words: Concrete, Compressive strength, Quarry Dust, Replacement,.

Comparative study on Strength Characteristics of Concrete .

dust by 15% by weight of Cement, the compressive strength of cube is increased and any further addition of marble powder and quarry dust decreases the compressive strength. 3) As the water cement ratio is more, there is a decrease in workability. 4) Quarry dust .

Experimental Study on Utilization of Red Mud and Quarry .

Fine aggregate was replaced up to 60% Quarry dust and evaluating its compressive and splitting tensile strength of Red mud concrete. The optimum gained after 7 and 28 days curing period was found to be 20% Red mud (for mortar) and for the combination of both Red mud and Quarry dust was found to be 20% Red mud + 40% Quarry dust(for concrete).

Effect of Fly Ash on Mortar Mixes with Quarry Dust as Fine Aggregate

Feb 12, 2014 . Abstract. This paper presents the results of an experimental investigation carried out to evaluate the compressive strength and transverse.

application of quarry dust in concrete construction - Flat

An attempt has also been made to durability studies on Quarry Rock Dust when compared with the Natural Sand concrete. It is found that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are nearly 10% more than the conventional concrete.

IRJET- Experimental Study of Compressive Strength on Foam .

Experimental study of compressive strength on foam concrete with quarry dust and fly ash Shaikh Taufique Shaikh Shakil Qureshi1, Santosh Pandurang Bhise2, A. .

partial replacement of natural river sand with crushed rock . - Jkuat

Jul 27, 2013 . the suitability of those properties to enable quarry dust (Dehwah, 2012) to . Dust content increases to 30 %, the 28 days compressive strength increases . natural sand as fine aggregate in both concrete and mortar has been.

comparing the compressive strengths of concrete made with river .

Key word: Quarry dust, river sand, compressive strength, water cement ratio, . Concrete is a mixture of water, cement or binder and aggregates (fine and coarse.

Influence of Marble Powder Mortar and Concrete Mix - NBM & CW

The use of waste marble powder (dust) was proposed in partial replacement of . Three properties of concrete namely workability, compressive strength and .. A S S (2009) Properties of Green Concrete containing Quarry Rock Dust and.

Aging and Curing Temperature Effects on Compressive Strength of .

Jun 11, 2017 . materials from the lime stone quarry and the granite industry as a partial . Keywords: compressive strength; mortar; temperature; quarry dust;.

Compressive Strength of Mortar -Mix Ratio and Cube Test

Compressive strength of mortar is determined by using 2 inch or 50mm cubes as per ASTM C109 / C109M – Standard Test Method for Compressive Strength of Hydraulic Cement Mortars. Mortar is a combination of cement, sand mixed with water. It is used for .

59 SUBSTITUTION OF QUARRY DUST TO SAND FOR MORTAR …

Table 3. Comparison of compressive strength with group "A" Bricks V. COST ANALYSIS The cost of Brick masonry and Random rubble masonry in cement mortar 1:6 has been analysed with the average rates of materials in Coimbatore district in Appukutty et al: Substitution Of Quarry Dust To Sand For Mortar In Brick Masonry Works 61

AN EXPERIMENTAL STUDY ON STRENGTH OF HYBRID .

AN EXPERIMENTAL STUDY ON STRENGTH OF HYBRID MORTAR SYNTHESIS WITH EPOXY RESIN, FLY ASH AND QUARRY DUST UNDER MILD CONDITION P. Sudheer1, Dr.M.G. Muni Reddy2, Dr.S. Adiseshu3 1Assistant Professor, Department of Civil Engineering, MVGR College of Engineering, Vizainagaram, Andhra Pradesh, India.

An Experimental Study on Usage of Quarry Rock Dust as . - IJARET

. selection of cement are compressive strength at various stages, fineness, heat of hydration, .. sand with quarry dust for the same water cement ratio. Concrete.

Use of Quarry Dust to Replace Sand in Concrete - International .

Index Terms- Concrete, quarry dust, river sand, compressive strength. I. INTRODUCTION . Reinforced cement concrete work of all types of structures. This.

(PDF) Determination of Mortar Strength Using Stone Dust as a .

Test result indicates that, compressive strength of specimen mix with 35% of sand replacing stone dust and 3% of cement replacing stone dust increases 21.33%.

Strength of Quarry Dust Modular Bricks and Wallettes Under .

Jan 10, 2014 · The compressive strength of masonry can be verified using two methods namely the unit strength method and the prism test method. The characteristics of masonry are influenced by the properties of bricks and mortar. This paper reports the investigation made on the compressive strength of bricks manufactured using quarry dust as sand replacement.

compressive strength of concrete using lateritic sand and quarry .

compressive strengths for 1:1:2 mix, while 0.6 water/cement ratio exhibit better . Keywords: concrete, compressive strength, lateritic sand, quarry dust. 1.

COMPRESSIVE STRENGTH OF CONCRETE USING LATERITIC .

COMPRESSIVE STRENGTH OF CONCRETE USING LATERITIC SAND AND QUARRY DUST AS FINE AGGREGATE Joseph O. Ukpata1, Maurice E. Ephraim2 and Godwin A. Akeke1 1Department of Civil Engineering, Cross River University of Technology, Calabar, Nigeria 2Department of Civil Engineering, Rivers State University of Science and Technology, Port Harcourt, Nigeria

Strength and durability properties of concrete containing quarry rock .

that the compressive, flexural strength and Durability Studies of concrete made of Quarry Rock Dust are . Keywords: concrete, quarry rock dust, river sand, strength, properties, shrinkage. . The consumption of cement content, workability,.

Title of paper - NBRO

bulk density of fresh mortar and flexural and compressive strength of hardened mortar were examined for . Effective utilization of quarry dust to produce ready.

Use of stone powder in concrete and mortar as an alternative of sand

mortar found from stone powder which is 33.02 Mpa, shows that better mortar can . Key words: Stone powder, concrete, mortar, concrete, compressive strength.

Aging and Curing Temperature Effects on Compressive .

Jun 11, 2017 · Aging and Curing Temperature Effects on Compressive Strength of Mortar Containing Lime Stone Quarry Dust and Industrial Granite Sludge. Amin MN(1), Khan K(2), Saleem MU(3), Khurram N(4), Niazi MUK(5).

Overview on the Utilization of Quarry Dust as a . - Penerbit UTHM

May 7, 2018 . quarry dust with 0.6 of water to cement ratio. For normal concrete, mostly the compressive strength was found to increase with age.

An Experimental study on Effects of Quarry Dust as Partial . - Irjet

sand by quarry dust gives higher compressive strength than natural sand concrete. . quarry waste at the same cement content generally reduced the super.

A STUDY OF COMPRESSIVE STRENGTH OF MORTAR MIXING …

A STUDY OF COMPRESSIVE STRENGTH OF MORTAR MIXING FLYASH . 10%, 20% and 30% of quarry dust. Mold the mortar seizing of 5×5×5 cm. Cure mortar in the water and test the compressive strength under ASTM C109 (4) when the mortars have an age of 7, 14, 21 and 28 days.

behaviour of concrete on the use of quarry dust to replace . - ESTIJ

replacement of sand [5]. Voids present in quarry dust mortar were lesser as compared to that of sand hence higher compressive strength [6]. A comparatively.

Improved Concrete Properties Using Quarry Dust as Replacement .

Concrete is that pourable mix of cement, water, sand, and gravel that . The Compressive strength of quarry dust concrete continues to increase with age for all.

Research Article Study on Compressive Strength of Quarry .

Research Article Study on Compressive Strength of Quarry Dust as Fine Aggregate in Concrete K.ShyamPrakash 1 andCh.HanumanthaRao 2 Department of Civil Engineering, PVP Siddhartha Institute of Technology, Kanuru, Vijayawada, Andhra Pradesh, India

Suitability of Crushed Stone Dust as Fine Aggregate in Mortars

dust and natural river sand. 2. Mortar and masonry characteristics using Crushed stone dust and river sand a. Compressive strength of mortar b. Flow/workability.

Study on Strength of Innovative Mortar Synthesis with Epoxy Resin .

quarry dust and fly ash in order to moderate the cost of mortar. The main objective of this . Keywords: Fly-ash, Quarry Dust, Epoxy Resin, Compressive Strength.

Determination of Mortar Strength Using Stone Dust as A Partially .

Test result indicates that, compressive strength of specimen mix with 35% of sand replacing stone dust and 3% of cement replacing stone dust increases 21.33%.

An Experimental study on compressive strength of Quarry .

The compressive strength results of quarry dust concrete (cubes) were obtained where M20 grade of concrete with 10 percent increment up to 100 percent replacement of quarry dust is concentrated and the results are presented. The study aimed to observe the compressive strength properties of quarry dust by varying full percentage

Partial Replacement of Sand with Quarry Dust in . - Semantic Scholar

as partial replacement for cement to have higher workability, long term strength and to make the concrete more economically available. This present work is an . in concrete. Key Words: Quarry Dust, Fly ash, Workability, Compressive strength.

Investigation of usability of quarry dust waste in fly ash .

Aug 30, 2019 · There was, however, only a 7% difference in compressive strength between the specimens cured for 3 and 5 h. An increase in NaOH molarity led to an increase in compressive strength. As the amount of quarry dust increased, the compressive strength of the 3M and 6M series increased slightly.

An Experimental Study On Usage Of Quarry Dust As Partial .

of cement content, workability, compressive strength and cost of concrete made with Quarry Rock Dust . Ilangovan (Studies on Strength and Behavior of Concrete by using Quarry Dust as Fine Aggregate) reported that Natural Sand with Quarry Dust as full replacement in concrete as possible with proper treatment of Quarry Dust before utilization .

Study on Compressive Strength of Quarry Dust as Fine .

(c) The compressive strength results of quarry dust concrete (cubes) were obtained in the third series, where M20, M25, and M30 grades of concrete with 20, 25, and 30 percent replacement of quarry dust and also workability are studied by varying the water-cement ratio …

Study on Strength of Innovative Mortar Synthesis with .

The main objective of this work is to study the compressive strength of mortar cubes by various combinations of cement and fine aggregate replaced by Epoxy resin, fly ash, and quarry dust at the .

Aging and Curing Temperature Effects on Compressive .

Keywords: compressive strength, mortar, temperature, quarry dust, . (40 and 60 °C) was observed on the strength development of mortars containing GS. Specifically, the compressive strength of mortar containing 10% GS was comparable to CM or corresponding mortar containing FA up to 28 days and at all ages under moderately high (40 °C) and .

Investigating Strength Properties of Geopolymer Concrete .

The results indicated that geopolymer concrete achieved comparably equal strength to that of the reference concrete mixture at a 100% quarry dust level. External exposure and ambient curing can be practiced to attain comparable strength properties of geopolymer concrete with quarry dust .

Effect on strength properties of concrete by using . - SSRG Journals

caused decreases in unit weights and compressive strength values of . compressive strength, saw dust Fly Ash on Mortar Mixes with Quarry Dust as Fine.

Aging and Curing Temperature Effects on Compressive .

Jun 11, 2017 · Keywords: compressive strength, mortar, temperature, quarry dust, granite sludge. . (40 and 60 °C) was observed on the strength development of mortars containing GS. Specifically, the compressive strength of mortar containing 10% GS was comparable to CM or corresponding mortar containing FA up to 28 days and at all ages under moderately high .

Effect of line powder as a partial replacement of crushed .

line powder in repair mortar and concrete application would offer technical, . permeability and using mineral additives increased compressive strength . The utilization of sands rich in fines like line quarry dust may be a.

Crushed rock sand – An economical and ecological alternative to .

In each case, the cube compressive strength test, and beam flexure tests . of its constituent raw materials namely, cement, aggregates (coarse and fine) and water. . strength and the durability properties of concrete made of quarry rock dust.

influence of quarry dust in concrete - YouTube

Feb 15, 2016 . Key Words: Quarry Dust, Fly ash, Workability, Compressive strength. . by quarry dust in concrete can quarry dust replace sand in a cement.

Comparing the compressive strenghths of concrete made with river .

Jul 20, 2014 . (compressive strength) to that obtained from conversional concrete made . Quarry dust; river sand; compressive strength; water cement ratio;.

What is the 7th day compressive strength of cement mortar .

NOTE : Compressive strength of cement can not be tested as such, because if the cubes are made out of pure cement, the cement shrinks, and cracks start to appear just as the water evaporates. Since appearance of cracks is taken as the start of fai.

Strength of Concrete with Ceramic Waste and Quarry Dust as .

This research focuses on a study of the strength of concrete with ceramic waste as coarse aggregate and quarry dust as fine aggregate. The sources of ceramic waste and quarry dust are obtained from the industrial in Malaysia. Presently, in ceramics industries the production goes as waste, which is not under going the recycle process yet. In this study an attempt has been made to find the .

(PDF) Study on Compressive Strength of Quarry Dust as Fine .

The concept of replacement of natural fine aggregate by quarry dust which is highlighted in the study could boost the consumption of quarry dust generated from quarries. By replacement of quarry dust, the requirement of land fill area can be reduced

Effect of Crusher Dust as Partial and Fully Replacement of . - IJESI

Dec 19, 2017 . Keywords: crusher dust, compressive strength, concrete,split tensile strength, . aggregates form the main matrix of concrete or mortar.

Compressive Strength of Fly Ash Brick with Addition of Lime .

Key words : Fly ash, Lime, Gypsum, Quarry dust, Compressive strength and . Least quantity of cement and fly ash has been used as binding materials and.

mechanical and durability properties of concrete by using . - IJAERD

material because of its actual compressive strength and durability. . cement 7.5% the strength is augmented by adding the pottery powder scrutiny . Keywords: Pottery powder, Metakaolin,, Brick powder, and Quarry dust, acid attack, chloride.

PROPERTIES OF FaL-G HOLLOW MASONRY BLOCKS - IJRET

Keywords: fly ash, lime, gypsum, quarry dust, sand, mortar, hollow blocks. .. Figure 3 indicates the compressive strength of FaL-G bricks at the age of 7,14,28,.

pre:types and specifications of hammer millnext:crushing screening